• 中文核心期刊
  • CSCD来源期刊
  • 中国科技核心期刊
  • CA、CABI、ZR收录期刊

响应面优化鼓槌石斛花总黄酮提取工艺及其体外抗氧化活性

Response Surface Optimization of Flavonoid Extraction and in Vitro Antioxidant Activity of Extract from Dendrobium Chrysotoxum Lindl. Flowers

    摘要
  • 摘要:
      目的  优化鼓槌石斛花总黄酮提取工艺条件，为鼓槌石斛花种质的开发提供技术参考。
      方法  以鼓槌石斛花为原料，乙醇溶液为提取剂，在单因素的基础上，选择乙醇体积分数、液料比、超声温度、超声时间4个因素为影响因素，鼓槌石斛花总黄酮提取率为响应值，采用Box-Behnken试验设计方法，研究各自变量及其交互作用对鼓槌石斛花总黄酮提取率的影响。并通过鼓槌石斛花总黄酮对1，1-二苯基-2-三硝基苯肼（DPPH）自由基、羟自由基的清除作用评价其抗氧化活性。
      结果  鼓槌石斛花总黄酮最佳提取工艺条件为：乙醇体积分数83%，液料比31 mL·g-1，超声温度59℃，超声时间44 min，在此条件下，得到的实际提取率9.71 mg·g-1，与理论值（9.60 mg·g-1）相对误差为1.15%。采用响应面法优化鼓槌石斛花总黄酮提取工艺切实可行，回归模型拟合度及重现性较好。鼓槌石斛花黄酮对DPPH自由基半清除浓度（IC50）值为11.30 μg·mL-1，其清除能力是L-抗坏血酸的0.51倍、2，6-二叔丁基对甲酚（BHT）的1.42倍；对羟自由基IC50值为137.26 μg·mL-1，其清除能力是L-抗坏血酸的0.70倍、BHT的1.95倍。体外抗氧化活性试验表明，相同浓度下其对两种自由基清除能力优于BHT，弱于L-抗坏血酸。
      结论  采用响应面法优化得出的鼓槌石斛花总黄酮提取的最佳工艺条件，能有效提高总黄酮提取率。

     

    Abstract:
      Objective  Extraction process of flavonoids from the flowers of Dendrobium chrysotoxum Lindl. was optimized, and the antioxidative activity of the extract determined in vitro.
      Method  Flowers of D. chrysotoxum was subjected to an ethanol extraction for flavonoids. The resulting yield was weighed against the processing conditions based on the single-factor tests and Box-Benhnken center composite experiment with four factors including ethanol volume fraction, solvent-to-substrate ratio, temperature, and time of ultrasonic treatment. The antioxidant capacity was estimated by the ability of the extract to scavenge 1, 1-diphenyl-2-picrylhydrazyl (DPPH) and hydroxyl free radicals.
      Result  The optimized processing conditions were determined to include ethanol volume fraction at 83%, solvent-to-substrate ratio at 31 mL·g-1, temperature at 59℃ and ultrasound application for 44m to obtain up to 9.71 mg·g-1 of total flavonoids in the extract. The yield exceeded the theoretically expected 9.60 mg·g-1 with a relative deviation of 1.15%. The in vitro tests showed an IC50 for DPPH to be 11.30 μg·mL-1, a scavenging ability 0.51-time of L-ascorbic acid or 1.42-time of BHT, while that for hydroxyl radicals, 137.26 μg·mL-1, a scavenging ability 0.70-time of L-ascorbic acid or 1.95-time of BHT.
      Conclusion  The optimized flavonoid extraction paved the way for scale-up utilization of D. chrysotoxum flowers.

     

    • HTML全文
    • 参考文献(29)
    • 相关文章
    • 施引文献
  • 资源附件(0)

/

返回文章
返回